Register to reply

Need help dehydrating liquid fruit blends

Share this thread:
Dvoorhees
#1
Mar11-14, 04:22 PM
P: 1
I am trying to understand the best way to dehydrate water from a liquid slurry fruit and vegetable blend, without loosing any of the vitamins and nutrition from the slurry. I expect to very thinly spread out the fruit/vegetables on a sheet, use dried convection air to help with the dehydrating, but keep the temperature of the slurry below 130 F.

Beyound using heat to evaporate the water, are there any othe ways to just cause the water molicules to more readily evaporate without damaging the nutrient content of the fresh fruit/vegetable slurry and preferably using low cost energy; microwaves, light wavelengths, radiant heat, sound waves, added solutions, , etc. Just looking for some idea/suggestions to investigate.

Thanks in advance,

David
Phys.Org News Partner Chemistry news on Phys.org
Chemical biologists find new halogenation enzyme
Protein secrets of Ebola virus
Protein courtship revealed through chemist's lens
manifespo
#2
Mar11-14, 10:18 PM
P: 8
Vacuum or freeze drying
Straw_Cat
#3
Mar19-14, 05:41 AM
P: 54
A combination of both freezing and then applying a strong vacuum would do the trick. This is what is termed 'freeze drying' and used in the food industry to prepare dried food stuffs. When a vacuum is applied to the frozen food, the water content sublimes from the solid state to the gaseous state without going through the liquid state.

This is also a good way to save important books, photographs, documents etc, from water damage if they've been flooded. It is advice given out by the National Library of Canada if a library, , or similar facility has been flooded, say when the building's plumbing fails. The first thing you should do is put the books in a deep freeze/ freezers then arrange to have them processed by a freeze drying facility. (that's the expensive part...)

Or until one can get a hold of a vacuum pump and build their own DIY vacuum chamber(s)...

The upside of freeze drying food is that there is almost no nutrient loss compared to heating the food.

There's probably a wiki entry about this subject....


Register to reply

Related Discussions
Grafting fruit trees on non-fruit ones Biology 5
Where to get polymer blends? General Engineering 1
Dehydrating agents Chemistry 10
Pascal's Law - pressure inside the liquid vs. force needed to lift the liquid Introductory Physics Homework 1
Dehydrating cyclohexanol Biology, Chemistry & Other Homework 2