Speedometer worm gear ratio changes

In summary, the design of the speedometer gear allows for changes in the number of teeth without any changes to the driving worm gear. This allows for many different gear combinations to be used to restore speedometer accuracy.
  • #1
jb5point0
1
0
When changing rear end gear ratios, or tire sizes on a vehicle, you can buy different speedometer gears with tooth counts to restore speedometer accuracy. The worm(driver) is inside the transmission and is not changed. It is a 7 or 8 tooth in my application. The speedometer gear(driven) is replaceable and comes in 15 to 23 tooth counts.

Just wondering which engineering design principles are allowing tooth changes in the driven gear without any changes in the driving worm gear or in the center to center distances of the gear set.

Some design parameter is taking a beating i suspect.
 
Engineering news on Phys.org
  • #2
jb5point0 said:
When changing rear end gear ratios, or tire sizes on a vehicle, you can buy different speedometer gears with tooth counts to restore speedometer accuracy. The worm(driver) is inside the transmission and is not changed. It is a 7 or 8 tooth in my application. The speedometer gear(driven) is replaceable and comes in 15 to 23 tooth counts.

Just wondering which engineering design principles are allowing tooth changes in the driven gear without any changes in the driving worm gear or in the center to center distances of the gear set.

The center to center distance stays the same. It is the outside diameter of the driven gear that changes. Even so there is a limit to how far one can go without having to change the drive gear. The teeth can still be cut to fit the worm gear.

I have always presumed that it was the difference in outside diameter of the driven gears that made it all work.

I remember that the old Muncie four speeds had a about six different numbers of teeth on the driven gear that it could accommodate without having to change the drive gear.

We can thank the aftermarket for the nine zillion combinations that are available.

The newer cars have gone electronic with a magnet located on a gear and no cable. Some new VW's even use one of the antilock brake sensors to send the signal.

Edit: OK those little alarm bells in my head just rang. The center to center distance stays the same because the hole in the side of the transmission is eccentric to the drive gear. Turning the driven gear housing to the right makes the gears mesh. This allows several size gears and numbers of teeth to be used.:redface:
 
Last edited:

1. What is a speedometer worm gear ratio?

A speedometer worm gear ratio is a measurement that describes the relationship between the rotation of a speedometer cable and the rotation of the speedometer needle. It is typically expressed in a ratio format, such as 1:1, which means that for every full rotation of the cable, the needle will also rotate one full revolution.

2. How does the speedometer worm gear ratio affect the accuracy of the speedometer?

The speedometer worm gear ratio directly affects the accuracy of the speedometer. If the ratio is not properly calibrated, the speedometer needle will not accurately reflect the speed of the vehicle. A higher gear ratio will result in a slower reading, while a lower gear ratio will result in a faster reading.

3. Can the speedometer worm gear ratio be changed?

Yes, the speedometer worm gear ratio can be changed. This is typically done by replacing the existing gear with one that has a different number of teeth. This will alter the relationship between the cable and the needle, resulting in a different gear ratio.

4. What are the reasons for changing the speedometer worm gear ratio?

The speedometer worm gear ratio may need to be changed for a few reasons. One common reason is to correct for tire size changes, as larger or smaller tires can affect the accuracy of the speedometer. Another reason is to adjust for changes in gear ratios, such as when upgrading to a different transmission or differential.

5. How can the speedometer worm gear ratio be determined?

The speedometer worm gear ratio can be determined by counting the number of teeth on the gear. The gear ratio is then calculated by dividing the number of teeth on the cable gear by the number of teeth on the speedometer gear. Alternatively, the gear ratio can be found in the vehicle's service manual or by consulting a mechanic or dealership.

Similar threads

Replies
10
Views
2K
  • Mechanical Engineering
Replies
4
Views
2K
Replies
14
Views
24K
Replies
2
Views
3K
  • Mechanical Engineering
Replies
7
Views
4K
Replies
1
Views
5K
Replies
4
Views
2K
  • Mechanical Engineering
Replies
7
Views
2K
  • Other Physics Topics
Replies
15
Views
4K
  • Introductory Physics Homework Help
Replies
21
Views
3K
Back
Top