Max aircraft range - electric powered

by mheslep
Tags: aircraft, electric, powered, range
 PF Gold P: 3,098 I'm trying to come up with some ballpark ranges for RC electric powered aircraft. The literature I find so far on range, like the Breguet range equation, seems focused on mass change from fuel consumption which is not the case in battery powered electric aircraft. So I thought I would start from scratch for my edification and invite sanity checks. McKay's reference, here, provided guidance. Below I've substituted terms convenient for my design. Fundamentally, the maximum range is some optimal aircraft velocity x time aloft, and time aloft is the total energy carried divided by the rate at which it is used, i.e. power, corrected for the efficiency of the propulsion system: R = Vopt x (Ebatt/P) x ε where:R = maximum range Ebatt = energy capacity of the battery ε = propulsion efficiency P = powerand since force is power / velocity: R = (Ebatt/Fthrust) ε for level flight: Fthrust = Drag Lift = mg or Fthrust = mg (D/L)where:m = aircraft mass g = gravity L/D = well known lift to drag ratio, or the glide ratio.then R = Ebatt x ε x (L/D) / mg Ebatt = Cbatt x me where:Cbatt = battery specific energy me = mass of batteryletfbatt = fraction of aircraft mass dedicated to the battery and me = fbatt mthenR = Cbatt x fbatt x m x ε x (L/D) / (mg) finally:R = ( Cbatt/g ) x fbatt x ε x (L/D) The term fbatt x ε x (L/D) is dimensionless. The fundamental range dependent on just carried energy is C/g. Next up, some numbers.
 PF Gold P: 3,098 Li Ion batteries are just short of 1 megajoule per kg, so in SI units C=1e6, g=10, the 'fundamental' range of a Li Ion powered aircraft is C/g = 100 km (62 miles). That applies to any aircraft so powered, of any size and air frame BTW. Now for the dimensionless bit, the parameters. Propulsion efficiency: ε = ηbatt x ηfan x ηemotor Common efficiencies for the battery and the motor are ~93%. If a prop maxes out at 85%, I'm guessing a duct-ed fan w/ vanes can also hit 93%, making the overall efficiency a convenient ε=0.8 Glide Ratio: Best powered aircraft glide ratio to my knowledge is the Virgin Atlantic Global flyer. The Flyer achieved an L/D = 37. Battery mass fraction: I don't know. Commercial aircraft like a 747 top off with f=0.5. I'm guessing I can stuff f=0.6 in the airframe. This RC 'Global Flyer' design gives a multiplier of fbatt x ε x (L/D) = 17.8 so Rmax li-ion = 1780 km (1100 miles)
 PF Gold P: 1,160 I have some literature on electric ducted fans that I think gives some expressions for range and endurance, but I don't have it with me right now.
 PF Gold P: 1,432 Max aircraft range - electric powered Buy a blimp covered in flexible photo-voltaic materials. (sorry. just had to subscribe to my favorite topic. )
 PF Gold P: 3,098 I note 1 MJ/kg takes the electric Flyer from New York to Bermuda (774 miles). Lithium Sulfur has demonstrated 1.26 MJ/kg, which would extend Rmax to 1390 miles. Still wont' cross the Atlantic (Newfoundland to Scotland) at 1900 miles
 PF Gold P: 3,098 Ah, a Lithium primary battery (no recharge) Li thionyl chloride goes to 1.8MJ => 1980 miles. Primary batteries are often low power density though.
PF Gold
P: 3,098
 Quote by jhae2.718 I have some literature on electric ducted fans that I think gives some expressions for range and endurance, but I don't have it with me right now.
Look forward to it.
 PF Gold P: 3,098 Interestingly, I see an RC 'model' aircraft (i.e. less than 11 pounds) crossed the Atlantic for the first time in 2003, using 2.2 kg of fuel (Coleman stove fuel). http://en.wikipedia.org/wiki/The_Spirit_of_Butts_Farm
 PF Gold P: 3,098 I see the glide ratio of some modern jets is 20:1. So to build an electric regional jet w legs of a 1000 mi (1700km), battery energy density needs to improve less than 2X, to 1.8 mj/kg: R=180km * .8 * .5 * 20. That is, as soon as an e motor comes along w the same specific power of a gas turbine fan engine (7kw/kg).
PF Gold
P: 1,160
 Quote by mheslep Look forward to it.
I was mistaken, it doesn't have anything on range. There are some equations for static thrust, power required, though. Let me know if you want those.

The booklet is from 1977, and is "Ducted Fans for Light Aircraft" by R.W. Hovey.
PF Gold
P: 3,098
 Quote by jhae2.718 I was mistaken, it doesn't have anything on range. There are some equations for static thrust, power required, though. Let me know if you want those. The booklet is from 1977, and is "Ducted Fans for Light Aircraft" by R.W. Hovey.
Thanks. That reference led me to another which cites Hovey.