Flyback diode to prevent back voltage

  • Thread starter Thread starter NATURE.M
  • Start date Start date
  • Tags Tags
    Diode Voltage
AI Thread Summary
Using a TB6612FNG motor driver to control two DC motors requires careful consideration of flyback diode placement to prevent back voltage damage. A 1N4001 diode can be connected in parallel across the motor, but when motors can spin in either direction, the connection becomes complex. Diodes should be connected from the motor terminals to ground to limit voltage spikes and protect the driver. Using Schottky diodes is suggested for their lower leakage and better reverse voltage capabilities. Failing to connect the diodes to ground could result in damaging voltage spikes below ground level.
NATURE.M
Messages
298
Reaction score
0
So I am currently using TB6612FNG motor driver (see https://www.sparkfun.com/products/9457) to drive two dc motors. Now I wanted to connect a flyback diode (1n4001) to prevent any potential damage to the motor driver that may occur from the back voltage of the dc motors after I terminate the power. Normally, if the motor was only running in a single direction it wouldn't be an issue, as I can easily hook up the diode in parallel across the motor. Since I'm controlling a motor that can spin in either direction, I'm not entirely sure how to connect the diodes as to prevent back voltage to the driver. Thanks.
 
Engineering news on Phys.org
So I was looking at this schematic for the diodes http://cdn.instructables.com/FYE/O8QZ/H21CGJYJ/FYEO8QZH21CGJYJ.LARGE.jpg and I'm trying to understand why are diodes connected from ground to motor terminals ??
 
You can put in 2 diodes per motor terminal so the voltage won't go much below ground or above the power supply. That will protect the attached components (assuming they can handle the slight rise above the supply or fall below ground). If there is a problem with that, you can use schottky diodes (check leakage and reverse voltage capability).
 
What if I hooked up only 4 diodes and did not hook up the 4 diodes connected to ground? (Based on the schematic given above).
 
Then the voltage could spike below ground and damage the driver.
 
Hi all I have some confusion about piezoelectrical sensors combination. If i have three acoustic piezoelectrical sensors (with same receive sensitivity in dB ref V/1uPa) placed at specific distance, these sensors receive acoustic signal from a sound source placed at far field distance (Plane Wave) and from broadside. I receive output of these sensors through individual preamplifiers, add them through hardware like summer circuit adder or in software after digitization and in this way got an...
While I was rolling out a shielded cable, a though came to my mind - what happens to the current flow in the cable if there came a short between the wire and the shield in both ends of the cable? For simplicity, lets assume a 1-wire copper wire wrapped in an aluminum shield. The wire and the shield has the same cross section area. There are insulating material between them, and in both ends there is a short between them. My first thought, the total resistance of the cable would be reduced...
I am not an electrical engineering student, but a lowly apprentice electrician. I learn both on the job and also take classes for my apprenticeship. I recently wired my first transformer and I understand that the neutral and ground are bonded together in the transformer or in the service. What I don't understand is, if the neutral is a current carrying conductor, which is then bonded to the ground conductor, why does current only flow back to its source and not on the ground path...
Back
Top