Troubleshooting Battery Chain Circuit for Motor Operation

AI Thread Summary
A user is troubleshooting a battery chain circuit for a motor and reports that five out of six batteries show no voltage after leaving the switch open overnight. The circuit involves connecting multiple batteries in series, with concerns about whether the batteries can discharge each other or if a closed circuit is necessary. Responses suggest checking the switch functionality, caution against soldering directly to batteries, and considering accidental wire contact. The type of batteries used is also questioned, as typical dry cells last years while rechargeable batteries may self-discharge over months. The discussion emphasizes the need for careful examination of the circuit setup to identify the issue.
Greenfish
Messages
2
Reaction score
0
Hello, I'm new here, and I need help with a problem. I'm sure there is a really easy answer to this, but I don't know what it is. I can't find it googling, probably because it is so obvious to everyone else.
But I have a circuit, which requires multiple batteries to opperate. Too combine their voltage, I had the negative terminal of one soldered to the positive of the next, so one and so one in a chain. Then the positive end of that chain I soldered a wire, connected it to a motor, and then through the other part of the motor, to a switch, back to the negative end of the chain. But I had found, after leaving the switch open overnight, that 5 of the 6 batteries had not voltage (according to a multimeter), did the batteries discharge each other, or do they need the circuit to be closed for that?
Any help whatsoever would be very much appreciated.
 
Engineering news on Phys.org
If you truly have everything hooked how I read it from your description then it seems strange that you would have 5 dead cells after a short time. This is an acceptable way to wire batteries.
 
Okay, thanks a lot then!
 
As per the last if what you say is accurate then there appears no clear reason.
1) can you test your switch to make sure it is open when it is supposed to be
2) I do not recommend soldering directly to batteries it is possible to damage them
3) is it possible that wires were accidentally touching
You did not say what type of batteries were used but typical dry cells can last several years , and rechargeables like Nicads can self discharge but usually only over months, so if they did discharge then there was a reason however unlikely.
Ray.
 
While I was rolling out a shielded cable, a though came to my mind - what happens to the current flow in the cable if there came a short between the wire and the shield in both ends of the cable? For simplicity, lets assume a 1-wire copper wire wrapped in an aluminum shield. The wire and the shield has the same cross section area. There are insulating material between them, and in both ends there is a short between them. My first thought, the total resistance of the cable would be reduced...
Hi all I have some confusion about piezoelectrical sensors combination. If i have three acoustic piezoelectrical sensors (with same receive sensitivity in dB ref V/1uPa) placed at specific distance, these sensors receive acoustic signal from a sound source placed at far field distance (Plane Wave) and from broadside. I receive output of these sensors through individual preamplifiers, add them through hardware like summer circuit adder or in software after digitization and in this way got an...
I am not an electrical engineering student, but a lowly apprentice electrician. I learn both on the job and also take classes for my apprenticeship. I recently wired my first transformer and I understand that the neutral and ground are bonded together in the transformer or in the service. What I don't understand is, if the neutral is a current carrying conductor, which is then bonded to the ground conductor, why does current only flow back to its source and not on the ground path...
Back
Top